The effect of transport density and gender on stress indicators and carcass and meat quality in pigs
Abstract
A total of 168 finishing pigs were used to investigate the effects of gender (barrows and gilts) and transport densities for slaughter (236, 251, and 275 kg/m²) on stress indicators and carcass and pork quality. The animals transported at 251 kg/m² (T251) presented cortisol values below those at 236 kg/m2 (T236), but no different from those at 275 kg/m2 (T275). The lactate dehydrogenase (LDH) values in pigs transported at T236 were the lowest. The blood components did not differ between T236 and T275. The pH values at 45 min (pH45) and at 24 h (pH24) postmortem were higher for pigs subjected to T236. However, the pH45 was higher at T251 than at T275, but pH24 was lower at T251 than at T275. The lightness values in the muscles of the pigs transported at T236 and T251 were higher than those at T275. Lower drip loss values were observed in the muscle of animals at T251. Carcasses of pigs at T236 contained more 1–5 cm lesions while those at T275 contained more 5–10 cmlesions in sections of loin. No significant effects of gender were found on the stress indicators, blood components, pH45, pH24, color, drip loss or carcass lesions in general. These results indicate that the pre-slaughter transport of pigs at densities of 251 kg/m² generates less physiological damage and smaller losses on carcass and pork quality irrespective of gender.
Downloads
References
ABPA, 2014. Estatísticas. Produção brasileira carne suína 2004 a 2013. Brazilian Association of Animal Protein. Available in http://www.abipecs.com.br/.
Araújo AP, 2009. Manejo pré-abate e bem-estar dos suínos em frigoríficos brasileiros. Master's thesis. Univ. Estadual Paulista, Botucatu, Brasil. 123 pp.
Araújo AP, 2012. Influência do sistema aspersão e tempo descanso suínos sobre o bem-estar e a qualidade da carne. Doctoral thesis. Univ. Estadual Paulista, Botucatu, Brasil. 115 pp.
Athayde NB, Dalla Costa OA, Roça RO, Guidoni AL, Ludtke CB, Oba E, Takahira RK, Lima GJ, 2013. Stress susceptibility in pigs supplemented with ractopamine. J Anim Sci 91: 4180-4187. http://dx.doi.org/10.2527/jas.2011-5014
Averós X, Herranz A, Sanchez R, Comella JX, Gosalvez LF, 2007. Serum stress parameters in pigs transported to slaughter under commercial conditions in different seasons. Vet Med 52: 333-342.
BRASIL, 1995. Normas técnicas instalações e equipamentos para abate e industrialização suínos. Ministério da Agricultura, Pecuária e Abastecimento, Secretaria Desenvolvimento Rural. Portaria n. 71, 1 novembro 1995. Diário Oficial da União. Brasília, DF, Brasil: 1-100.
Bryer PJ, Sutherland M, Davis BL, Smith JF, Mcglone JJ, 2011. The effect transport and space allowance on the physiology of breeding age gilts. Livest Sci 137: 58-65. http://dx.doi.org/10.1016/j.livsci.2010.09.026
Chai J, Xiong Q, Zhang CX, Miao W, Li FE, Zheng R, Peng J, Jiang SW, 2010. Effect of pre-slaughter transport plant on blood constituents and meat quality in halothane genotype of NN Large White×Landrace pigs. Livest Sci 127: 211-217. http://dx.doi.org/10.1016/j.livsci.2009.09.014
Correa JA, Torres S, Devillers N, Laforest JP, Gonyou HW, Faucitano L, 2010. Effects of different moving devices at loading on stress response and meat quality in pigs. J Anim Sci 88: 4086-4093. http://dx.doi.org/10.2527/jas.2010-2833
Dalla Costa OA, Faucitano L, Coldebella A, Ludke JV, Peloso JV, Dalla Roza D, Paranhos Da Costa MJR, 2007. Effects of the season of the year, truck type and location on truck on skin bruises and meat quality in pigs. Livest Sci 107: 29-36. http://dx.doi.org/10.1016/j.livsci.2006.08.015
Dalla Costa OA, Ludke JV, Paranhos da Costa MJR, Faucitano L, Peloso JV, Dalla Roza D, Coldebella A, 2009. Efeito do jejum na granja e condições de transporte sobre o comportamento dos suínos de abate nas baias de descanso e lesões na pele. Ciên Anim Bras 10: 58-68.
EC, 2005. Council Regulation n.1/2005 on the protection of animals during transport and related operations and amending Directives 64/432/EEC and 93/119/EC and Regulation (EC) No 1255/97. Official Journal of the European Union, L3, 22/12/2004, pp: 0001-0044.
Faucitano L, 2001. Causes of skin damage to pig carcasses. Can J Anim Sci 81: 39-45. http://dx.doi.org/10.4141/A00-031
Gajana CS, Nkukwana TT, Marume U, Muchenje V, 2013. Effects of transportation time, distance, stocking density, temperature and lairage time on incidences of pale soft exudative (PSE) and the physico-chemical characteristics of pork. Meat Sci 95: 520-525. http://dx.doi.org/10.1016/j.meatsci.2013.05.028
Herrera MB, Spilsbury MA, Ortega ME, Guerrero-Legarreta I, Ramírez-Necoechea R, Roldan-Santiago P, Pérez-Sato M, Soní-Guillermo E, Mota-Rojas D, 2010. Changes in blood constituents of swine transported for 8 or 16 h to an abattoir. Meat Sci 86: 945-948. http://dx.doi.org/10.1016/j.meatsci.2010.07.021
Honikel KO, 1998.Reference methods for the assessment of physical characteristics of meat. Meat Sci 49: 447-457. http://dx.doi.org/10.1016/S0309-1740(98)00034-5
Kaneko JJ, Harvey JW, Bruss ML, 1997. Clinical biochemistry of domestic animals, 5th ed. Academic Press, New York. 932 pp.
Ludtke CB, Ciocca JRP, Dandin T, Barbalho PC, Vilela JA, Dalla Costa OA, 2010. Abate humanitário suínos. WSPA, Rio de Janeiro. 128 pp.
Ludtke CB, Dalla Costa OA, Roça RO, Silveira ETF, Athayde NB, Araújo AP, Mello Júnior A, Azambuja NC, 2012. Bem-estar animal no manejo pré-abate e a influência na qualidade da carne suína e nos parâmetros fisiológicos do estresse. Ciên Rur 42: 532-537. http://dx.doi.org/10.1590/S0103-84782012000300024
Mota-Rojas D, Becerril M, Lemus C, Sánchez P, González M, Olmos SA, Ramírez R, Alonso-Spilsbury M, 2006. Effects of mid-summer transport duration on pre- and post-slaughter performance and pork quality in Mexico. Meat Sci 73: 404-412. http://dx.doi.org/10.1016/j.meatsci.2005.11.012
Mota-Rojas D, Becerril-Herrera M, Roldan-Santiago P, Alonso-Spilsbury M, Flores-Peinado S, Ramírez-Necoechea R, Ramírez-Telles JA, Mora-Medina P, Pérez M, Molina E, et al.,2012. Effects of long distance transportation and CO2 stunning on critical blood values in pigs. Meat Sci 90: 893-898. http://dx.doi.org/10.1016/j.meatsci.2011.11.027
National Pork Board, 2008. Transport quality assurance handbook. Available in http://www.pork.org/filelibrary/TQA/manual.pdf. [20 May 2013].
Ochove VCC, Caramori Jr JG, Correa GSS, Bertoloni W, Roça RO, Silva GS, Cruz RAS, 2010. Influência da distância no bem-estar e qualidade carne suínos transportados em Mato Grosso. Rev Bras Saú Prod Na 11: 1117-1126.
Pereira TL, Corassa A, 2014. Fluxo do transporte de suínos para abate no Estado de Mato Grosso. Rev Bras Saú Prod An 15: 970-982. http://dx.doi.org/10.1590/S1519-99402014000400022
Pérez MP, Palacio J, Santolaria MP, Acena MC, Chacon G, Gascon M, Calvo JH, Zaragoza MP, Beltranf JA, García-Belenguer S, 2002. Effect of transport time on welfare and meat quality in pigs. Meat Sci 61: 425-433. http://dx.doi.org/10.1016/S0309-1740(01)00216-9
Perre VV, Permentier L, Bie SD, Geers R, 2010. Effect of unloading, lairage, pig handling, stunning and season on pH of pork. Meat Sci 86: 931-937. http://dx.doi.org/10.1016/j.meatsci.2010.07.019
Pilcher CM, Ellis M, Rojo-Gomes A, Curtis SE, Wolter BF, Peterson BA, Peterson MJ, Ritter MJ, Brinkmann J, 2011. Effects of floor space during transport and journey time on indicators of stress and transport losses of market-weight pigs. J Anim Sci 11: 3809-3818. http://dx.doi.org/10.2527/jas.2010-3143
Piñeiro M, Piñeiro C, Carpintero R, Morales J, Campbell FM, Eckersall PD, Toussaint MJM, Lampreave F, 2007. Characterisation of the pig acute phase protein response to road transport. Vet J 173: 669-674. http://dx.doi.org/10.1016/j.tvjl.2006.02.006
Robina A, Viguera J, Perez-Palacios T, Mayoral AI, Vivo JM, Guillen MT, Ruiz J, 2013. Carcass and meat quality traits of Iberian pigs as affected by sex and crossbreeding with different Duroc genetic lines. Span J Agric Res 11: 1057-1067. http://dx.doi.org/10.5424/sjar/2013114-4637
SAS, 2003. System for Microsoft Windows: release 8.2. SAS Inst. Inc., Cary, NC (USA) [cd-rom].
Souza AP, Mota LL, Zamadei T, Martim CC, Almeida FT, Paulino J, 2013. Classificação climática e balanço hídrico climatológico no Estado de Mato Grosso. Pesquisas Agrárias e Ambientais 01: 34-43. http://dx.doi.org/10.14583/2318-7670.v01n01a07
Sutherland MA, Krebs N, Smith JS, Dailey JW, Carroll JA, Mcglone JJ, 2009. The effect of three space allowances on the physiology and behavior of weaned pigs during transportation. Livest Sci 165: 13-18. http://dx.doi.org/10.1016/j.livsci.2009.06.021
Sutherland MA, Bryer PJ, Davis BL, Smith JF, Mcglone JJ, 2012. The combined effects of transport and food and water deprivation on the physiology of breeding age gilts. Livest Sci 144: 124-131. http://dx.doi.org/10.1016/j.livsci.2011.11.005
Warriss PD, Brown SN, Knowles TG, Edwards JE, Kettlewell PJ, Guise HJ, 1998. The effect of stocking density in transit on the carcass quality and welfare of slaughter pigs: 2. Results from the analysis of blood and meat samples. Meat Sci 50: 447-456. http://dx.doi.org/10.1016/S0309-1740(98)00057-6
© CSIC. Manuscripts published in both the printed and online versions of this Journal are the property of Consejo Superior de Investigaciones Científicas, and quoting this source is a requirement for any partial or full reproduction.
All contents of this electronic edition, except where otherwise noted, are distributed under a “Creative Commons Attribution 4.0 International” (CC BY 4.0) License. You may read here the basic information and the legal text of the license. The indication of the CC BY 4.0 License must be expressly stated in this way when necessary.
Self-archiving in repositories, personal webpages or similar, of any version other than the published by the Editor, is not allowed.
